9.2. Safety locks, the relay and plaits of wires

Fig. 9.1. Placing of safety locks on the block of safety locks and the relay, located in car salon: F1—F14 — safety locks; 1 — the relay of screen wipers; 2 — the relay of indexes of turn and the emergency light alarm system; 3 — the relay of back antifog lanterns; 4 — a sound signalling device of excess of speed

Fuses are placed in blocks of safety locks and the relay in a motor compartment and in car salon (fig. 9.1, 9.2).

Fig. 9.2. Placing of safety locks on the block of safety locks and the relay, located in a motor compartment: Ef11 - Ef21 — safety locks; 1 — the relay of high frequency of rotation of the fan of a radiator; 2 — the main relay; 3 — the ignition relay; 4 — the relay of forward antifog headlights; 5 — the relay of low frequency of rotation of the fan of a radiator; 6 — the illumination relay; 7 — the conditioner relay; 8 — the relay of headlights; 9 — the relay of a sound signal

Always replace a safety lock with other safety lock of the same capacity. On each safety lock its size of rated current is specified. Do not replace a safety lock more than once, without having defined its reason перегорания. If the safety lock has fused, means, the conductor connecting contacts of a safety lock is broken off.

Establish the new safety lock calculated on the same size of a current. On an underside of each safety lock the size of a protected current is specified.

If the established safety lock again has fused, check up the electric chain protected by a safety lock.

Do not replace a safety lock with a wire crosspiece as it is possible to damage an electric chain of the car seriously.

The chains protected by safety locks, are resulted in tab. 9.1.

Table 9.1 the     Chains protected by safety locks

Safety lock designation	Current, And	Source	Protected chains
Safety locks in the block of safety locks and the relay in a motor compartment
Ef2	40	The storage battery	The ignition switch, the block of safety locks of the control panel (F11-F13)
Ef3	10	The storage battery	The switch of giving of fuel (the inertial switch)
Ef4	10	Ignition 1	Fuel, the generator, the gauge of speed, the relay of the fuel pump, the main relay, the ignition coil
Ef5	-	-	It is not used
Ef6	20	The storage battery	The engine of the fan of a heater
Ef7	15	The storage battery	Heater of back glass
Ef8	10	The storage battery	Headlight headlight, the right party
Ef9	10	The storage battery	Headlight headlight, left-hand side
Ef10	10	The storage battery	Headlight passing light, the right party
Ef11	10	The storage battery	Headlight passing light, left-hand side
Ef12	10	58	Back lanterns and illumination lanterns, the right party
Ef13	10	58	Back lanterns and illumination lanterns, left-hand side
Ef14	10	The storage battery	The conditioner compressor
Ef15	30	The storage battery	The radiator fan
Ef16	10		The spare
Ef17	10	The storage battery	Sound signal
Ef18	20	The storage battery	The relay of headlights, the headlight switch
Ef19	15	The storage battery	The electronic block of management, the main relay
Ef20	15	The storage battery	Forward antifog headlights
Ef21	15		The spare
The safety locks located in the block of safety locks and the relay in salon of the car
F1	10	Ignition 1	The panel of devices, hours
F2	10	Ignition 1	SDM
F3	25	Ignition 1	The switch of an emergency light signal
F4	10	Ignition 1	Lamps of a signal of turn
F5	15	The storage battery	Stoplight
F6	10	Ignition АСС	Audiosystem
F7	20	Ignition АСС	Прикуриватель
F8	15	Ignition 2	Screen wiper
F9	15	Ignition 2	The engine of a back screen wiper, forward and back washers of glass, backing lantern
F10	10	Ignition 2	The electric drive of external rear-view mirrors
F11	10	Ef2	Audiosystem, plafond of illumination of salon
F12	15	Ef2	Emergency light signal, hours
F13	20	Ef2	The electric drive of locks of doors
F14	20	Starter	The starter engine

Fig. 9.3. An arrangement of plaits of wires and sockets in a motor compartment: 1 — the gauge of double pressure; 2 — a forward right antifog headlight; 3 — the gauge of pressure of the hydraulic booster of a wheel; 4 — socket G102; 5 — the right headlight; 6 — the gauge of the right forward wheel; 7 — the block of management ABS; 8 — the valve of an absorber of steams of fuel; 9 — socket С101; 10 — socket С205; 11 — socket С202; 12 — socket С206; 13 — the gauge of the left forward wheel; 14 — socket С102; 15 — the left headlight; 16 — a sound signal; 17 — socket G101; 18 — a forward left antifog headlight; 19 — the radiator fan; 20 — the gauge of opening of a cowl; 21 — the electronic block of management

Fig. 9.4. An arrangement of plaits of wires and sockets on the engine: 1 — the oxygen gauge; 2 — the gauge of temperature of a cooling liquid; 3 — the valve of the control of idling; 4 — the valve рециркуляции the fulfilled gases; 5 — the gauge of position throttle заслонки; 6 — the gauge of temperature of air in an inlet collector; 7 — the optical gauge; 8 — to the electronic block of management; 9 — the switch of a lamp of a backing; 10 — the valve of the control of idling; 11 — the gauge of position throttle заслонки; 12 — the valve рециркуляции the fulfilled gases; 13 — the detonation gauge; 14 — In + the generator; 15 — socket G103; 16 — the gauge of temperature of air in an inlet collector; 17 — the optical gauge

Fig. 9.5. An arrangement of plaits of wires and sockets on a body: 1 — socket С362 (for right-hand management); 2 — socket С361; 3 — the illumination switch at doors of the forward passenger; 4 — socket С381; 5 — the gauge of a back right wheel; 6 — right back динамик; 7 — the right plafond of illumination; 8 — socket G402; 9 — the fuel pump; 10 — the gauge of a back left wheel; 11 — socket С371; 12 — the illumination switch at doors of the driver; 13 — the seat belt gauge; 14 — socket С351; 15 — socket С352 (for link sided management); 16 — the gauge of a lay brake; 17 — socket G301

Fig. 9.6. An arrangement of plaits of wires and sockets: And, In — the zones shown on fig. 9.5; 1 — socket С203; 2 — socket С202; 3 — socket С201; 4 — socket С204; 5 — socket С205; 6 — socket С206; 7 — left back динамик; 8 — socket С401; 9 — socket С402; 10 — socket G401; 11 — the left plafond of illumination

Fig. 9.7. An arrangement of plaits of wires and sockets of a forward door: 1 — a drive of the lock of a door; 2 — the engine стеклоподъемника; 3 — a regulator of position of an external rear-view mirror; 4 — sockets С351, С352; 5 — forward динамик

Fig. 9.8. An arrangement of plaits of wires and sockets of a back door: 1 — a drive of the lock of a door; 2 — the engine стеклоподъемника; 3 — socket С371

Fig. 9.9. An arrangement of plaits of wires and sockets of a cover of a luggage carrier: 1 — socket С402; 2 — a socket of a back heater of glass; 3 — the central stoplight; 4 — the engine of a back screen wiper; 5 — a plafond of illumination of licence plate; 6 — socket С403; 7 — socket С401; 8 — socket G404; 9 — socket G403

Connections of elements of system of ignition, electrical supply, electrostart-up, illumination, the light alarm system, instrumentations and the additional equipment are carried out by plaits of wires with sockets. The arrangement of plaits of wires in a motor compartment, on the engine, a body, in forward both back doors and a luggage carrier cover is shown on fig. 9.3, 9.4, 9.5, 9.6, 9.7, 9.8, 9.9.